Ski-Doo Snowmobiles Forum banner
1 - 8 of 8 Posts

·
Registered
Joined
·
4 Posts
Discussion Starter · #1 ·
I have the typical lighting and gauge issues on my sons 500ss, and have replaced the Relay.

seemed a little better, but they only work at higher RPM's, and the lights really are not full brightness, even at higher RPM's.

Thinking it could be the voltage regulator (if there is one).

Can anyone tell me where this is located?

Does this sound like a Stator issue?

Thanks!
 

·
Registered
Joined
·
34 Posts
Open side panel on exhaust side, deep down on right is regulator. Stator on that side too inside the case. I have both for sale if you need either.

Sent from my iPhone using Tapatalk
 

·
Registered
Joined
·
4 Posts
Discussion Starter · #3 ·
Open side panel on exhaust side, deep down on right is regulator. Stator on that side too inside the case. I have both for sale if you need either.

Sent from my iPhone using Tapatalk
Thanks

I am assuming you need to pull the exhaust can?
 

·
Registered
Joined
·
7,506 Posts
you can get to the regulator by removing the just the tuned pipe.

the vr is just in front of the pull starter.. bolted to the tunnel

you can test the stator at the plug that goes into the regulator

double check the voltage coming out of the vr.. i have seen some relay harnesses go bad and cause problems

hope this helps
 

·
Registered
Joined
·
4 Posts
Discussion Starter · #5 ·
you can get to the regulator by removing the just the tuned pipe.

the vr is just in front of the pull starter.. bolted to the tunnel

you can test the stator at the plug that goes into the regulator

double check the voltage coming out of the vr.. i have seen some relay harnesses go bad and cause problems

hope this helps
Thank you!
 

·
Registered
Joined
·
4 Posts
Discussion Starter · #7 ·
Open side panel on exhaust side, deep down on right is regulator. Stator on that side too inside the case. I have both for sale if you need either.

Sent from my iPhone using Tapatalk
Just noticed you have a VR for sale. New? Price? thanks
 
1 - 8 of 8 Posts
Top