Ski-Doo Snowmobiles Forum banner
voltage regulator
1-20 of 36 Results
  1. REV-XP/XS Chassis: Perf. Trail 120-129 Inch Models
    I have a 08 MXZ X 800r power-Tek. It will not charge the battery to more then 11.5v. The sled will pull start and run fine. If I disconnect the battery and put my meter on it the voltage jumps around, I am kind of surprised it will run. I have a shop manual and went through all the checks...
  2. Skandic / Expedition
    Folks. The voltage regulator in the 2014 Skandic is broken. Have the new one and wading into changing it. Seems the sled is built around the voltage regulator. Almost hard to see. I'm thinking the best way in is to loosen the track, pull the transmission, pull the jack shaft, drain the...
  3. MXZ / Legend / Summit / Grand Touring / Formula
    My stock hand warmers melted the grips right around the same time all my lights conked out-- head, tail, and instrument. I installed a new voltage regulator and now the lights are fine (new bulbs of course), but the warmers don't warm. I assume they are cooked, just like the bulbs-- unless...
  4. MXZ / Legend / Summit / Grand Touring / Formula
    Hello Everyone, First time sledder/poster here... I recently put a new battery in my 2000 GT 800 SE triple. All was dandy for a short while until it died on me....dead battery. So my charging system isn't working. I got it going manually, used a meter to test voltage while running, sure...
  5. Skandic / Expedition
    I have a 2002 Skandic WT with 500F engine. I am replacing the voltage regulator but the replacement part has different wire colors and plug style. Can someone help me with the correct wires to connect. My machine voltage regulator has Black, Red, Yellow and Green. My new voltage regulator...
  6. Skandic / Expedition
    Where is the voltage regulater on a 82 Alpine 640ER? I only have 6-8 volts at my battery when at idle...8-10 when reving. Is it most likely this is the problem? Machine runs perfect except for this.
  7. Vintage Ski Doo's
    We did a motor swap on a tundra, 250 for 250 with higher compression. During the swap, we took the old connectors out and installed a 4 flat trailer light connecter. Shortly after the swap, the headlight started going on and off. Now it only will light on low beam, and very dim. I put...
  8. REV-XP/XS Chassis: Perf. Trail 120-129 Inch Models
    trying to sort out my voltage problem with a lazy stator shows no charge at battery ( same voltage as battery engine off) pull headlight fuse voltage jumps to 14 with engine running stator was tested at three yellow wires at voltage regulator behind chaincase , this is accessable by removal...
  9. REV Chassis - Performance and Trail Models
    Looking for some direction from you experienced sled owners that have had electrical problems. I picked up a used 07 Rev with 600 SDI elect start. Sled is running like a champ but in my last outing I blew 2 break lights and lost my thumb & hand warmers. We were sledding in negative 10 degree...
  10. REV-XP / XM Chassis - Mountain Sleds
    Hi guys, I have a 2008 summit 800r I'm having an issue with.. My sled is only running on one cylinder. The sled is only running on the mag side cylinder at idle. If I unplug the mag side plug cap I can get it to run on the pto side, but at soon as I plug the mag side back in it drops the pto...
  11. REV Chassis - Performance and Trail Models
    My friend just rebuilt his top end on a 2008 GTX 600 (not HO) . It ran like a champ but after a few miles it died and would not restart until it cooled off. Then it would run for a few miles and cut out again. Once cooled the sled runs like a champ then cuts very abruptly - not like its...
  12. MXZ / Legend / Summit / Grand Touring / Formula
    I picked up a 1995 touring e this year for my daughter and everything worked great on it. The battery was shot and didn't charge, but it pulled over fine and ran well. We've taken it out for a couple rides and suddenly all the lights went out, including the dash lights. Based on some reading...
  13. Freestyle / Legend / Tundra / Expedition Sport
    Hey guys, I am a little stumped on something here. I am trying to wire in a 12 volt plug. Based on what I've read I can use the bomber kit. However I need to run a heater for my enclosed equinox sleigh that we tow behind for the kids. I have soldered the red power wire to the yellow wire on the...
  14. Skandic / Expedition
    I just inherited a 2006 SUV with the 550 fan from a dear friend.. It has 2200 miles and is in excellent condition. When i first drove it, i noticed both headllamps and the tail light were inoperative. Handwarmers were warm but not hot. The blue highbeam light also doesn't work (maybe because the...
  15. MXZ / Legend / Summit / Grand Touring / Formula
    I just bought a used '97 Grand Touring. The owner told me that the voltage regulator was probably not working as the lights were all blown. I ran the sled and the AC voltage was all over the map, from too high to too low. I have pulled out the VR and it definitely is bad, new one on order...
  16. Sledding - General Discussion
    I have two sleds both the same a GTX 550F and an Expedition 550F last spring when we were putting the Ex. away suddenly the head lamps burned out, don't know if they both burned out at the same time or not, but at least the last one did, we switched to low beam and when we gave the machine a rev...
  17. Sled Parts For Sale or Trade
    Item: 550f Calibrated Module & Voltage Reg Category: Sled Year: 2007 Location: 99752 Price: Best Offer 550f Calibrated Module Part# 512060157 & Voltage Rectifier Regulator Part# 515176189 from a 2007 Ski-Doo Expedition Sport. I can post pictures if interested. PM offer if interested.
  18. REV Chassis - Performance and Trail Models
    I'm new to this forum, so hello everyone. I have a 05 skidoo rev 600 ho sdi. Here is the issue, I went to go for a ride last week and I hit the rer/start button to wake up the sled. Nothing! No gauges no priming, nothing. Battery is charged, switch works. I also tried pulling it and sounds...
  19. Freestyle / Legend / Tundra / Expedition Sport
    I need to change the voltage regulator on my 2007 Expedition Sport V-800. I can't seem to find it under the hood. I've changed them before in my older sleds, but am not a mechanic and in a hurry. Can anyone tell me how to get at it and where it is? Thanks!
  20. REV Chassis - Performance and Trail Models
    Went north for the weekend and started sled on saturday morning, notice oil light was on and tach not working but ran fine also headlights did not work, let sled sit all day and returned from all day ride and started it. Ran fine and everything worked. loaded sled inside trailer for the night...
1-20 of 36 Results
Top