Search Results for ‘overheating’

Was riding along great last weekend when right ski hit something hard but not enough to damage anything with the suspension. Within a minute it goes into limp mode and is overheating. I immediately stop and see coolant leaking out underneath. Coolant bottle is spraying out. This week I stripped...

Hi, I have an 07 Summit XRS and I bought it used and its been running without issue. Overheating light came on after about 50 km on hard pack trail. Got it back to the trailer and now in the shop at home here. A bit of research suggest changing the thermostat - no problem I thought. My...

After extension from 120 to 129 (tunnel and rail extension) my sled is always running hot. Anyone else run into this? Any fixes besides tearing down and getting longer exchanger? Sled is 12 mxzx 800r.

Greetings! I am a rookie owner of a new 2019 Grand Touring 600r etec living in northern Minnesota. Wife and I took new sled out for first time and we overheated and limped home after about six minutes of riding. Outside temp was -14. We rode on a marginally plowed township road and a trail with...

I have a 2015, a 2016, a 2017 and a 2018 Ski Doo Renegade 600 Carb and they are all overheating on me after riding for not very long. I also have a 2016 Ski Doo MXZ Blizzard 800 which does not overheat on me. Here are some things that I have tried to see if it could help the sleds stop...

my 2016 blizzard 800r e-tec temp climbs into the 156*-170* degree range on hard packed snow seem normal ?? another issue is i have filled my coolant bottle up to the cold line before a trip 126 miles and for some reason the next day checked it and its was low again whats up with that i did...

My 2016 xrs overheats trail riding at times, it's inconsistent. Last ride was 3 miles of lake on each end of a 6 mile trail. Ran about 56 deg C on the trail heading out, overheated on the way back, alarms at around 86 C went up to 92C. Air temp was about -25 C with loose snow on the trail...

My buddy has an 800R etec Summit 164'' 3'' paddle that over heats just idling and will go into shutdown mode then shut engine off. It will run idling for about 5-7 mins then go into shutdown mode. Outside temp is around 0 degrees celcius or 32 F. If there is good powder snow the sled will...

So I had a bad fuel pump on the old 440. When i changed it out I decided to put on new clear fuel hoses and by the way why not clean out the oil reservoir of that old dark mineral oil and fill it with some nice red synthetic oil that we use in our other sled. no other changes were made. Well it...

I've had a couple of occasions when my sled has overheated and it didn't make sense to me. Both times we were running in cold weather (-5 to 0 degrees F) with hard packed trails but with and inch of powder on top for cooling and lubrication. Plenty of snow spraying out of the sled in front of...

I have two 2004 Legend 700, each with about 1300 miles on them. I bought them used at the end of last season. In the off season I had them completely gone over to ensure they would be ready this year. The coolant was drained, system flushed, new thermostats installed, filled with 50/50 premix...

Hello This is my first entry into this amazing and informative site. I have just purchased this used sled (2007 600cc SDI GTX Sport Skidoo.).. I have been out of the sledding scene for over 10 years and have just returned. I have heard that on this machine the clutches overheat because the...

Is it bad to turn my heated carburetor valve off in -35 c weather? My Ski doo mxz sport 600 keeps over heating,any suggestions? Ps. Its been around -15 to -40 for the past few weeks, and it still over heats ridin on the roads.

Got my 11 renegade BCX 800etec rebuilt last spring under the factory rebuild (crankshaft went at 1400 miles) I went riding near abbotsford wisconsin, got through the break-in and then the overheating started. The light came on probably 10 times during my 550 mile trip and everytime i stopped as...

Happy thanksgiving. Just got an awesome deal on my 1st sled. Got caught up in the glory of sledding. Didn't think I'd run into technical issues already. Sled is overheating! Checked hoses for proper config. Any suggest?

My 2011 800 etech renegade adrenaline will start beeping then shut off if it sits at idle for a few minutes. I thought this was over heating so I installed a temperature sending unit. Now if I switch the setting on the instrument cluster from the gas gauge to the temperature gauge it will show...

I have a 2010 SWt v800 with about 2500 miles on it, was out with it the other day and noticed that the exhaust pipes were cherry red (could see it through the vent screen on the hood right side) pulled over and noticed that my tub near the right front shock was starting to melt. It was 6 degees...

Ok so i went for my first ride on my new to me 04 summit and it was awesome at first but about 5 min into the ride i started getting idle hang not from not back shifting it kept me moving. It would go away with a few blips of the throttle. Then about 15 min into the ride i noticed a little bit...

First ride on 13 Renagade 800x 25 miles from Jackman Maine just crossed into Canada and engine overheated. Ride shutdown and ride shutdown for 15 miles long afternoon made it to St. George. Dealer had to put in a used thermostat, continued on for 600 mile trip trails were great.

2009 Summit Hillclimb, RK Tek 860. Water pump shaft Snapped in half.. What would cause this? Everything in motor is new, well besides the water pump which I should have done while I did everything else, Hind sight, lol..