Ski-Doo Snowmobiles Forum banner

Discussions Showcase Albums Media Media Comments Tags Marketplace

1-20 of 31 Results
  1. REV-XP/XS Chassis: Perf. Trail 120-129 Inch Models
    Hey guys I just picked up a premium gauge from a 2011 renegade and was wondering if it will plug and play on my 2008 renegade SDi 600. If I plug it in will it be OK? I also have the controller but noticed that the harnesses are different for the premium hand controller. All I’m looking to get...
  2. Engine FAQs
    Hey Everyone, I recently just bought a 2004 Skidoo GSX 600 H.0 SDI with no motor. I do however have everything from the throttle bodies, injectors, exhaust ext. I am not overly familiar with the fuel injection machines because I’ve always run carb machines. I have a couple questions regarding...
  3. REV Chassis - Performance and Trail Models
    2004 gsx 600 ho sdi battery light flashes with a beep while riding/ running. replaced battery- no resolve replaced stator- no resolve wile off after sitting for 2 hours battery reads 12.9v- coso battery gauge when started battery will slowly taper off in voltage to 8 volts where it will...
  4. REV Chassis - Performance and Trail Models
    Hello I got a problem with my Skidoo Mxz Xrs 600sdi HO. The problem started from nowhere about a half year ago. I tought I did run out of fuel but that was not the case. The problem was that it was really hard to start and when you got it to start it would run really bad. Another problem was...
  5. REV Chassis - Performance and Trail Models
    My sled I noticed was using a lot more oil than it should. I compared my oil usage to my neighbors sdi that has a lot less miles on it. Always use the skidoo full synthetic oil in it. I pulled the exhaust pipe off the manifold and the right cylinder ( closest to the clutch) had oil running out...
  6. REV Chassis - Performance and Trail Models
    So this has become a headache. My sled (2005 skidoo mxz renegade 600 HO SDI) stopped charging about the same time my dash lights stopped going off when the sled shut off. Some dummy lights came on in the dash also. Started to tear into it and found the ground on the voltage regulator was broke...
  7. REV Chassis - Performance and Trail Models
    Looking for some help guys, Just rebuilt top and bottom end of my 04 mxz 600HO sdi after 12,000 kms on the clock. Got a MCB Performance kit comes with everything crank, pistons etc... fired up the rebuilt engine today runs perfect, let it run for about 30 mins then figured I would pull the plugs...
  8. Rev (2)

  9. REV Chassis - Performance and Trail Models
    Hey everyone, So I have an 06 renegade x with the 600sdi and after doing some preseason maintenance I noticed that with the belt off if I rotate the primary clutch by hand I can hear what appears to be a sort of screeching noise, now to provide some background the sled has 14000 miles (And no...
  10. REV Chassis - Performance and Trail Models
    Hey everybody, I have a 2004 MXZ Adrenaline 600 sdi. I had a Sno Stuff aftermarket can on it for the last couple months and it ran great. This weekend we are going trail riding so I put the stock can back on it and took it for a ride and it seems to lose power in the mid range briefly then kicks...
  11. Sledding - General Discussion
    I've been looking on craigslist for quite sometime for a can for my 2006 mxz 600sdi and haven't found a single seller! there is another can for sale that fits a 2009-2016 E-tec that looks almost identical to the can that fits my snowmobile (according to mbrp.com). I was wondering if there is...
  12. REV Chassis - Performance and Trail Models
    Hi, not sure if this has been addressed before but here goes:: Bought the sled at the beginning of the season and it never went over 80mph. I knew that was strange but never dug into it, figured bad gas or whatever. Now after putting 400 miles on it wont do over 63mph all of a sudden. I...
  13. General Discussion
    Hello everyone, i have a 2007 XRS 600 SDI and i managed to bend my main steering tube. unfortunately i am not able to order a new one or find one online or used anywhere so far. My question is from my understanding, the 07 XRS 600 SDI is basically the Rev 440x race chassis with a 600 trail...
  14. Sledding - General Discussion
    ANY REASON AN ENGINE (600SDI) OUT OF A 2005 EXPEDITION MODEL WOULD NOT GO INTO A 2005 REV?
  15. REV Chassis - Performance and Trail Models
    Got an 05 gsx 600sdi and after rebuild it Ran good for 500 feet then acts like a bad injector. Revved it up pretty good. 135/140# compression. Good spark. Did exactly the same thing last time, this is the second fuel rail and injectors. Doesn't go into reverse well without stalling either. Any...
  16. REV Chassis - Performance and Trail Models
    Hey guys, Just looking for some information on how to bleed my oil pump and lines after re-installing my motor. A little worried after hearing some horror stories about air in the pulse line. Should i run a bit of oil in my tank just incase? Thanks.
  17. REV Chassis - Performance and Trail Models
    Hi, when I start my sled my DESS light on the dash blinks twice, confirming that the right key is registered. The only thing is is that I don't get my two chips along with the dash light flashes. Even when placed in reverse there is no chirp. I cleaning the post and cap with rubbing alcohol and...
  18. Wanted To Buy
    I am looking for a motor for my 2007 skidoo summit adrenaline. Don't care if it's a 600ho 600sdi or 800r. It was my summer project and can't go a winter without riding.. school is coming up so money is tight, I could paint a vehicle or something labor free to work it off? I also polish aluminum...
  19. Sled Parts For Sale or Trade
    Item: 600 ho crank 600 sdi cylinder Category: Sled Year: na Location: sw mn Price: 150 Ive got a good used 600 ho crank and a real nice 600 sdi cylinder. 200 for the crank and 150 for the cylinder. Message me if interested as I dont check my listings much. Thanks
  20. REV-XP/XS Chassis: Perf. Trail 120-129 Inch Models
    Hi just have a quick question about a JAWS can that i'm looking at buying. The can is coming off of a 2008 mxz 600sdi and wondering if it will fit my 2010 mxx 600 carb? Thanks in advance for everyones input.
1-20 of 31 Results
Top