Search Results for ‘500ss’

I have a 2004 gsx 500ss sport and it won’t stay running, it bogs down even after being warmed up for a while. i figured the first thing to do since i had been sitting for a while was to put some fresh gas in and it did nothing. decided i’m best off rebuilding and cleaning the carbs. however i...

Hello! I recently purchased my first sled. My second time riding the sled it died and i realised it has locked up. I took it home Tore it down and one cylinder had big marks and so had the piston. The other one had some scratches and both postons had a big play. The crank has also a very big...

recently starting my 2008 500ss, I am no longer getting the double beep at start up. I used to get 4 regular sized beeps and shortly after the 2 short beeps. I am now only getting the 4 beeps and sometimes none at all. I am not sure about this dess system, because it never double beeps even...

Hey guys, I purchased a rev 500ss last year and the rer is not functioning. When I press the button, the sled stays idling and the rpm does not change. I am unsure which wires are used for the rer system and have traced a few that were unplugged and was wondering if they had anything to do with...

Is there a way to test a trigger coil? Can't find it by searching. Also, can the dealer test the ECM? I've tested the stator, checked all connections, tested wires for continuity, tried known-working coil and VR, replaced plugs, disassembled kill switch and cleaned the contacts (and tried...

Installed a set of these LED bulbs yesterday https://www.amazon.ca/RCP-Headlight-Conversion-Built-Warranty/dp/B01N0W026O/ref=sr_1_3?ie=UTF8&qid=1546095817&sr=8-3&keywords=h4+led They are permanently stuck with the high beams on, the high beam light on the dash stays on as well, Ive read about...

I have a 2005 500ss I put a set of crankshop factory pipes off a 800 I believe, I have it running alright but it needs a little more get up and go! I know the pipes need more porting and I am planning on sending out my mpem to be re mapped for the higher Rpm curve of the pipes. I was reading...

Hello All!! Time to start working on the sleds!! I have two 2005 500ss sleds that I've owned for a while now. Love them. Both ate their second sets of pistons at the end of last year (blew top ends on last trip of season). Each engine has around 14,000 miles on the crankshafts. Cranks are...

Hi guys, So I pulled an all nighter trying to finish a rebuild on the top end of my 2004 500ss. I actually did the motor this summer and reinstalled all but the reeds, carbs, rave valves, oil lines etc. I did everything to spec straight from the book. I rebuilt the rave valves and last night...

Hey guys, my buddie's 2008 TNT (500ss) throws a check engine light at startup, and beeps 4 times. This happened after starting up after a couple years, but seems to start and run normal. Light comes on immediately after restarting and stays on. Most of the topics I can find are in relation to...

I have a 05 500ss that I'm working on and at the same time I'm also getting ready to part out my 05 mach z 1000. So I am going to swap the sc3 skid for the sc4 as well as new x package shocks and springs. Aside from replacing the sliders while the skid is out, anything else I would never looking...

My front right ski is very wobbly when riding after I nicked something riding off trail when there was poor visibility. There's some play in the ski (I have the front end off the ground). No a-arm damage or ski damage. Ski's are both relatively new as well. I tried putting a washer in but it...

Now I recently heard about people having issues with their seats on the 08's and I thought I was the only one. My seat gets very hard when it gets real cold out. It's almost like it actually freezes over. And now that the seat is getting stained from my pants and mold is starting to get on it, I...

I just put a full top end in my 2005 500ss. After torquing everything to spec and buttoning everything up theres no spark when i pull it over. Last year i was riding and stopped and when i went to start it again it didnt have any spark but after i got home it did. what could it be? MPEM...

Hi, I have an '08 TNT I plan on putting a new track on before this season. I like to do off trail riding as well as some on trail too. I either want to get a Backcountry X 120x15x1.75, a Sno X 120x15x1.75, a Challenger Trail 120x16x1.75, and I'm also looking at the 2.0" Backcountry X2. Does...

Hello fellow sledders. I was out today in my 04 GSX 500ss playing in fresh powder and doing some carving. I was having some fun when i noticed my sled was going all the way up to 9000RPM with only a little bit of throttle. it sounded horrible and I wasn't getting all my potential power. How can...

hey guys, just got a new sled (04 Rev GSX500ss) and im having some problem with the oil level sensor or some sort of oil injection related sensor. ive been through the carbs, rebuild the fuel pump, new tank fuel filter and blew out all the fuel and vent lines, new carb boots, welded and patched...

trying to sort out my voltage problem with a lazy stator shows no charge at battery ( same voltage as battery engine off) pull headlight fuse voltage jumps to 14 with engine running stator was tested at three yellow wires at voltage regulator behind chaincase , this is accessable by removal...

2007 500ss no compression on cltch side.....possible causes?

Hey guys anyone run a ggb trail can? Look nice and really looking to buy one, just want to hear some reviews. For those who don't like cans, I'm talking about the trail can which is meant to be neighbor/land owner friendly and not too much louder over stock.